Predictive efficiency analysis of biomass boilers using tor-refied tropical fruit residues and washed wood waste

Hadi Prayitno; Ricky Syahputra Tarigan; Ahmad Fauzan; Aryanda Fitrah Fardano; Muhammad Hlimy Assydiqie; Murtadho Agung Pratama

doi:10.30811/jpl.v24i3.8722

Predictive efficiency analysis of biomass boilers using tor-refied tropical fruit residues and washed wood waste

Hadi Prayitno, Ricky Syahputra Tarigan, Ahmad Fauzan, Aryanda Fitrah Fardano, Muhammad Hlimy Assydiqie, Murtadho Agung Pratama

Abstract

Biomass-fired boilers are widely used in agro-industrial steam generation, yet their efficiency remains sensitive to fuel quality, boiler configuration, and the calorific value basis. This study developed a predictive thermal-efficiency assessment of four industrial biomass boilers, namely ZUG, Djaja Teknik, Vickers, and Isgec, by integrating biomass fuel characterisation, field operating data, and Hugot’s direct-efficiency model. Its novelty lies in linking calorific-value changes in torrefied tropical fruit residues and distilled water-washed wood waste to boiler-specific operating parameters, rather than treating fuel upgrading as laboratory fuel improvement alone. Gross Calorific Value (GCV) was used as the primary basis for modelling, while NCV efficiency was calculated only when supporting fuel data were available. Baseline results showed GCV-based efficiencies of 77.12% for ZUG and 80.63-81.05% for Djaja Teknik, whereas Vickers and Isgec corresponded more closely to NCV-based efficiencies of 72.24% and 68.71–70.34%, respectively. Distilled water washing changed wood-waste GCV from 3,891-4,812 to 4,343-5,323 kcal/kg, with champaca increasing by approximately 21.6%. Torrefaction yielded higher GCV values of 6,519.28, 6,661.58, and 6,875.60 kcal/kg for coffee husk, cocoa shell, and mangosteen shell, respectively. Under fixed-flow Hugot assumptions, higher GCV increased fuel-energy input and could reduce numerical ηGCV, indicating model sensitivity rather than poorer fuel performance. The findings support SDGs 7, 12, and 13 through renewable heat assessment, biomass residue valorisation, and low-carbon energy pathways, while remaining limited to predictive boiler thermal efficiency.

Keywords

Biomass boiler; torrefaction; washed wood waste; calorific value; Hugot model

Full Text:

PDF

References

S. E. Ibitoye, R. M. Mahamood, T. Jen, C. Loha, and E. T. Akinlabi, “An overview of biomass solid fuels : Biomass sources , processing methods , and morphological and microstructural properties,” J. Bioresour. Bioprod., vol. 8, no. 4, pp. 333–360, 2023, doi: 10.1016/j.jobab.2023.09.005.

W. Sun et al., “Simulation Study on Coal and Ammonia Co-Firing in a Tangential Firing Boiler Under Different Ammonia Injection Methods,” Sci. Rep., 2025, doi: 10.1038/s41598-025-98792-5.

A. Alifatul et al., “South African Journal of Chemical Engineering Engineering study of coal co-firing based on biomass mixture and slagging-fouling control in the steam power plant,” South African J. Chem. Eng., vol. 55, no. May 2024, pp. 191–221, 2026, doi: 10.1016/j.sajce.2025.11.008.

Y. Cheng et al., “Design of the Control and Remote Monitoring Energy System Based on an Embedded Biomass Boiler,” Front. Energy Res., 2024, doi: 10.3389/fenrg.2024.1434112.

M. Obradović, N. Karličić, D. Todorović, D. Radić, and A. Jovović, “Experimental Studies of Wood Chips Charactristics Influence on Boiler Performance and Pollutant Emissions,” Therm. Sci., 2023, doi: 10.2298/tsci2301121o.

H. Prayitno, H. Rustamaji, Y. Arafat, and A. Darma, “Thermochemical-Mechanical Assessment of Washed and Torrefied Biomass Co-Firing in Boilers for a Sustainable Energy Transition,” vol. 7, no. 1, pp. 99–116, 2026, doi: 10.46456/jisdep.v7i1.1010.

M. Elwardany, “Enhancing steam boiler efficiency through comprehensive energy and exergy analysis : A review,” Process Saf. Environ. Prot., vol. 184, no. January, pp. 1222–1250, 2024, doi: 10.1016/j.psep.2024.01.102.

D. Suntoro, P. Sinaga, R. C. Yudanto, and Faridha, “Energy Efficiency and Energy Saving Potential Analysis of Biomass Boiler at the PT Greenfields Indonesia Milk Processing Plant,” Iop Conf. Ser. Earth Environ. Sci., 2022, doi: 10.1088/1755-1315/1034/1/012012.

M. Z. U. Haq and H. M. Masood, “Performance enhancement of an industrial fire tube boiler”, JPIChE, vol. 48, no. 1, pp. 43–48, Nov. 2022. https://doi.org/10.54693/piche.04815

H. Prayitno, T. O. Ba’albaqi, M. D. Susila, and Harmen, “The Effect of Bagasse Waste Quality as Biomass Fuel on The Efficiency of Water Tube-Type Boilers”, Anal. Environ. Chem., vol. 9, no. 01, pp. 140–150, Sep. 2024. https://doi.org/10.23960/analit.v9i01.162

S. Guo, X. Deng, D. Zhao, S. Zhu, H. Qu, and X. Li, “An Optimized Method for Evaluating the Preparation of High-Quality Fuel from Various Types of Biomass through Torrefaction,” Molecules 2024, 29(8), 1889; https://doi.org/10.3390/molecules29081889

J. S. Tumuluru, B. Ghiasi, N. R. Soelberg, and S. Sokhansanj, “Biomass Torrefaction Process , Product Properties , Reactor Types , and Moving Bed Reactor Design Concepts,” vol. 9, no. September, pp. 1–20, 2021, doi: 10.3389/fenrg.2021.728140.

H. Prayitno, Amrul, R. Lestari, and R. Kurniawansah, “Potential Torrefaction of Tropical Forest Fruits Waste,” J. Phys. Conf. Ser., vol. 2739, no. 1, 2024, doi: 10.1088/1742-6596/2739/1/012005.

Amrul, A. Apriyanto, H. Prayitno, and M. S. azmar “Effect of residence time on the torrefaction characteristics of Calliandra wood as solid biofuel,” Polimesin, vol. 23, no. 3, pp. 293–300, 2025. http://dx.doi.org/10.30811/jpl.v23i3.6656

M. Bajcar, M. Zardzewiały, B. Saletnik, G. Zaguła, C. Puchalski, and J. Gorzelany, “Torrefaction as a Way to Remove Chlorine and Improve the Energy Properties of Plant Biomass,” Energies, 2023, doi: 10.3390/en16217365.

A. Nebyvaev, D. Klimov, А. Ryzhenkov and M. Brulé, “Preliminary Results of Innovative Two-Stage Torrefaction Technology Applied for Thermochemical Treatment of Sunflower Husk,” Processes, 2023, doi: 10.3390/pr11082486.

D. Wu et al., “Soybean Yield Response of Biochar-Regulated Soil Properties and Root Growth Strategy,” Agronomy, vol. 12, no. 6, 2022, doi: 10.3390/agronomy12061412.

X. Wang et al., “Flue Gas-Enhanced Water Leaching: AAEM Removal From Agricultural Organic Solid Waste and Fouling and Slagging Suppression During Its Combustion,” Acs Omega, 2023, doi: 10.1021/acsomega.3c00690.

M. N. Cahyanti, T. R. K. C. Doddapaneni, M. Madissoo, L. Pärn, I. Virro, and T. Kikas, “Torrefaction of agricultural and wood waste: Comparative analysis of selected fuel characteristics,” Energies, vol. 14, no. 10, pp. 1–19, 2021, doi: 10.3390/en14102774.

K. Bukhsh et al., “Comparative analysis of combustion behavior of raw and torrefied biomass pellets in a customized high-temperature flat flame furnace,” Fuel, vol. 404, no. PB, p. 136301, 2026, doi: 10.1016/j.fuel.2025.136301.

K. Bharadwaj, S. Shenbagaraj, P. Kumar, K. Sharma, P. Kumar, and W. Chen, “Biomass torrefaction : An overview of process and technology assessment based on global readiness level,” Fuel, vol. 324, no. January, p. 124663, 2022, doi: 10.1016/j.fuel.2022.124663.

N. S. Raghuvanshi, “Optimized Low‐Emission Combustion in Domestic Biomass Boilers: A Comparative Study Using Artificial Bee Colony Algorithm for Enhanced Efficiency and Reduced Pollutant Emissions,” Heat Transf., 2025, doi: 10.1002/htj.70096.

E. Hugot - Handbook of Cane Sugar Engineering (1986, Elsevier Science)

A. Klavina and R. Šeļegovskis, “Influence of Wood Chip Quality on Boiler House Efficiency,” 2021, doi: 10.22616/erdev.2021.20.tf082.

H. Rahmani, A. Algirdas, A. Shestavetska, and D. Vaiciukyniene, “Preparation and mechanical characterization of pressed carbonized wood sawdust bio- composite,” Sci Rep 15, 14981 pp. 1–17, 2025. https://doi.org/10.1038/s41598-025-98658-w

N. John, P. S. Fathima, V. S. Harsha, N. M. Paul, and P. Nisha, “Physical Conversion of Biomass: Dewatering, Drying, Size Reduction, Densification, and Separation. In: Thomas, S., Hosur, M., Pasquini, D., Jose Chirayil, C. (eds) Handbook of Biomass. Springer,” 2023. https://doi.org/10.1007/978-981-19-6772-6_37-1

D.-G. Lee, M.-J. Ku, K. Kim, J.-S. Kim, S.-M. Kim, and C. Jeon, “Experimental Investigation of the Ash Deposition Characteristics of Biomass Pretreated by Ash Removal During Co-Combustion With Sub-Bituminous Coal,” Energies, 2021, doi: 10.3390/en14217391.

X. Wang et al., “Flue Gas-Enhanced Water Leaching : AAEM Removal from Agricultural Organic Solid Waste and Fouling and Slagging Suppression during Its Combustion,” 2023, doi: 10.1021/acsomega.3c00690.

M. Farghali et al., “Strategies to Save Energy in the Context of the Energy Crisis: A Review,” Environ. Chem. Lett., 2023, doi: 10.1007/s10311-023-01591-5.

A. Javanmard, W. M. A. W. Daud, M. F. A. Patah, and C. Y. Ying, “Impact of water-washing pretreatment on key properties of torrefied palm kernel shells: A statistical optimization study,” Ind. Crops Prod., vol. 228, no. February, p. 120729, 2025, doi: 10.1016/j.indcrop.2025.120729.

A. Mukherjee, J. A. Okolie, C. Niu, and A. K. Dalai, “Experimental and Modeling Studies of Torrefaction of Spent Co ff ee Grounds and Co ff ee Husk : E ff ects on Surface Chemistry and Carbon Dioxide Capture Performance,” 2021, doi: 10.1021/acsomega.1c05270.

P. Basu, P., & Kaushal, Biomass Gasification, Pyrolysis, and Torrefaction. Elsevier, 2024. doi: 10.1016/C2022-0-02464-8.

R. Zahedi, A. Shaghaghi, M. T. Tahooneh, and A. Ahmadi, “Numerical simulation of combustion of sulfide- biomass concentrate ingredients and contaminants in copper furnace smelting,” Futur. Energy, vol. 2, no. 1, pp. 1–8, 2022, doi: 10.55670/fpll.fuen.2.1.1.

R. Nabila et al., “Oil palm biomass in Indonesia : Thermochemical upgrading and its utilization,” Renew. Sustain. Energy Rev., vol. 176, no. January, p. 113193, 2023, doi: 10.1016/j.rser.2023.113193.

J. V Reinoso-Moreno, M. G. Pinna-Hernández, M. D. Fernández, J. A. Sánchez-Molina, J. C. López Hernández, and F. G. Acién, “Boiler Combustion Optimization of Vegetal Crop Residues From Greenhouses,” Agronomy, 2021, doi: 10.3390/agronomy11040626.

J. Wang, Q. Yao, X. Jin, and L. Deng, “The Influence of Co-Firing Coal With Biomass Syngas on the Thermodynamic Parameters of a Boiler,” Appl. Sci., 2023, doi: 10.3390/app132011477.

W. Chen et al., “Progress in biomass torrefaction : Principles , applications and challenges,” vol. 82, 2021, doi: 10.1016/j.pecs.2020.100887.

R. Raman and A. Sreenivasan, “iScience Analyzing the contributions,” ISCIENCE, vol. 28, no. 4, p. 112157, doi: 10.1016/j.isci.2025.112157.

DOI: http://dx.doi.org/10.30811/jpl.v24i3.8722