Enhancing seawater desalination performance using a vortex generator in a modified window air conditioner

Nurkholid Nurkholid, Dan Mugisidi, Widodo Widodo, Oktarina Heriyani, Ibnu Sulistiono

Abstract


The growing demand for air conditioning systems has driven research into alternative applications, such as seawater desalination. This study evaluates the performance of a modified window air conditioner (WAC) integrated with a vortex generator for desalination. Experiments were conducted using R410A refrigerant under four conditions: closed container (CC), without vortex (WV), connected vortex (CV), and separated vortex (SV). Seawater was heated via the condenser to 55–60°C, controlled by a thermostat, and data was collected every five minutes over eight hours. The thermodynamic properties of R410A were analyzed using Refprop software to determine refrigeration effect (RE), compression work (CW), and coefficient of performance (COP). Results indicate that the SV configuration achieved the highest evaporation rate (5.01 kg) but led to a lower COP (3.91) due to increased condenser temperature and compressor workload. Conversely, CC yielded the highest COP (5.08) by stabilizing the evaporator air temperature and reducing compressor effort. These findings suggest that vortex generators enhance evaporation rates but reduce system efficiency. Further research is needed to optimize vortex generator configurations to improve desalination efficiency while minimizing COP reduction.


Keywords


Window air conditioner, Vortex generator, Desalination, Refprop, COP

Full Text:

PDF

References


P. Martínez, J. Ruiz, C. G. Cutillas, P. J. Martínez, A. S. Kaiser, and M. Lucas, “Experimental study on energy performance of a split air-conditioner by using variable thickness evaporative cooling pads coupled to the condenser,†Appl. Therm. Eng., vol. 105, pp. 1041–1050, 2016, doi: 10.1016/j.applthermaleng.2016.01.067.

M. H. Alhamdo, M. A. Theeb, and J. J. Abdulhameed, “Using evaporative cooling methods for improving performance of an Air-cooled Condenser,†Univers. J. Mech. Eng., vol. 3, no. 3, pp. 94–106, 2015, doi: 10.13189/ujme.2015.030304.

K. Harby, D. R. Gebaly, N. S. Koura, and M. S. Hassan, “Performance improvement of vapor compression cooling systems using evaporative condenser: An overview,†Renew. Sustain. Energy Rev., vol. 58, pp. 347–360, 2016, doi: 10.1016/j.rser.2015.12.313.

N. D. Purnama, T. P. Pramudantoro, and A. Badarufin, “Kaji eksperimental perbandingan performansi ac split sebelum dan sesudah pemanfaatan panas buang kondenser untuk alat penetas telur,†Pros. Ind. Res. Work. Natl. Semin., vol. 15, no. 1, pp. 64–70, 2024, doi: 10.35313/irwns.v15i1.6242.

N. I. Ibrahim, A. A. Al-Farayedhi, and P. Gandhidasan, “Experimental investigation of a vapor compression system with condenser air pre-cooling by condensate,†Appl. Therm. Eng., vol. 110, pp. 1255–1263, 2017, doi: 10.1016/j.applthermaleng.2016.09.042.

M. W. Akram, R. Mursalin, M. M. Hassan, M. R. Islam, and S. K. Choudhury, “recycling of condensed water from an air conditioning unit,†in International Conference on Computer, Communication, Chemical, Material and Electronic Engineering, IC4ME2, IEEE, 2018, pp. 1–5. doi: 10.1109/IC4ME2.2018.8465612.

A. Gross and E. Park, “Water and wastewater treatment worldwide: The industry and the market for equipment and chemicals,†Bus. Econ., vol. 53, no. 2, pp. 37–47, 2018, doi: 10.1057/s11369-018-0069-1.

D. Mugisidi, A. Fajar, and H. Oktarina, “Peningkatan efisiensi dan efektivitas kondensor pada solar still,†J. Teknosains, vol. 12, no. 1, pp. 19–31, 2022.

J. J. Messakh, A. Sabar, I. K. Hadihardaja, and A. A. Chalik, “A study on fulfillment of drinking water need of people in semi-arid areas in Indonesia,†J. Mns. dan Lingkung., vol. 22, no. 3, pp. 271–280, 2015.

A. A. Ragetisvara and H. S. Titah, “Studi kemampuan desalinasi air laut menggunakan sistem sea water reverse osmosis (swro) pada kapal pesiar,†J. Tek. ITS, vol. 10, no. 2, pp. 68–75, 2021, doi: 10.12962/j23373539.v10i2.63933.

L. A. Yoshi and I. N. Widiasa, “Prosiding seminar nasional teknik kimia ‘kejuangan’ sistem desalinasi membran reverse osmosis (RO) untuk penyediaan air bersih,†in Prosiding Seminar Nasional Teknik Kimia “Kejuangan,†2016, pp. 1–7.

B. Shen and B. Fricke, “Development of high efficiency window air conditioner using propane under limited charge,†Appl. Therm. Eng., vol. 166, p. 114662, 2020, doi: 10.1016/j.applthermaleng.2019.114662.

A. E. Kabeel, M. Abdelgaied, and Z. M. Omara, “Experimentally evaluation of split air conditioner integrated with humidification-dehumidification desalination unit for better thermal comfort, produce freshwater, and energy saving,†J. Therm. Anal. Calorim., vol. 147, no. 6, pp. 4197–4207, 2022, doi: 10.1007/s10973-021-10810-6.

M. Abdelgaied, A. E. Kabeel, and Y. Zakaria, “Performance improvement of desiccant air conditioner coupled with humidification-dehumidification desalination unit using solar reheating of regeneration air,†Energy Convers. Manag., vol. 198, p. 111808, 2019, doi: 10.1016/j.enconman.2019.111808.

A. E. Kabeel, M. Abdelgaied, and Y. Zakaria, “Performance evaluation of a solar energy assisted hybrid desiccant air conditioner integrated with HDH desalination system,†Energy Convers. Manag., vol. 150, pp. 382–391, 2017, doi: 10.1016/j.enconman.2017.08.032.

P. Dalai, P. Nanda, C. Mund, D. Mishra, and A. Gupta, “An experimental study on water harvesting from a modified window air-conditioner,†Energy Procedia, vol. 109, pp. 253–260, 2017, doi: 10.1016/j.egypro.2017.03.058.

D. Mugisidi and O. Heriyani, “Improving the performance of a forced-flow desalination unit using a vortex generator,†CFD Lett. , vol. 16, no. 10, pp. 81–93, 2024, doi: 10.37934/cfdl.16.10.8193.

A. N. Shmroukh, A. A. Serageldin, A. Abdal-hay, A. Elreedy, and A. Radwan, “Application of new series connection scheme of vortex tubes in seawater desalination unit using new vortex generators,†SN Appl. Sci., vol. 3, pp. 1–13, 2021, doi: 10.1007/s42452-021-04205-3.

O. Heriyani, M. Djaeni, Syaiful, and A. K. Putri, “Perforated concave rectangular winglet pair vortex generators enhance the heat transfer of air flowing through heated tubes inside a channel,†Results Eng., vol. 16, pp. 1–15, 2022, doi: 10.1016/j.rineng.2022.100705.

J. Williams, “Desalination in the 21st Century: A Critical Review of Trends and Debates,†Water Altern., vol. 15, no. 2, pp. 193–217, 2022.

Widodo, F. Rachmanu, and A. I. Tauvana, “analysis of savings on electricity consumption in room air conditioning by using r1270 (propylene) refrigerant instead of R32 capacity of 13,000 Btuh,†J. Phys. Conf. Ser., vol. 1477, no. 5, pp. 1–6, 2020, doi: 10.1088/1742-6596/1477/5/052035.

I. G. A. Negara et al., “Real-time thermodynamic monitoring of split inverter ACs: a microcontroller-driven investigation of performance,†J. Polimesin, vol. 22, no. 2, pp. 199–205, 2024.

R. Wirangga, D. Mugisidi, A. T. Sayuti, and O. Heriyani, “The impact of wind speed on the rate of water evaporation in a desalination chamber,†J. Adv. Res. Fluid Mech. Therm. Sci., vol. 106, no. 1, pp. 39–50, 2023, doi: 10.37934/arfmts.106.1.3950.

E. W. Lemmon, I. H. Bell, M. L. Huber, and M. O. McLinden, “NIST Standard reference database 23: reference fluid thermodynamic and transport properties-REFPROP, version 10.0, National Institute of Standards and Technology.â€

M. L. Huber, E. W. Lemmon, I. H. Bell, and M. O. McLinden, “The NIST REFPROP database for highly accurate properties of industrially important fluids,†Ind. Eng. Chem. Res., vol. 61, no. 42, pp. 15449–15472, 2022, doi: 10.1021/acs.iecr.2c01427.

Widodo, B. Fajar, T. Suryo, and Winoto, “Simulation of mixing synthetic with hydrocarbons refrigerant to reduce the value of global warming potential with refprop software,†J. Phys. Conf. Ser., vol. 1764, no. 1, pp. 1–6, 2021, doi: 10.1088/1742-6596/1764/1/012158.

M. E. Pujianto and A. Nugroho, “Performance air conditioner on retrofitted refrigerant hydrocarbon,†J. Polimesin, vol. 22, no. 1, pp. 15–18, 2024, doi: 10.1063/1.5049962.

K. Sumeru, M. Arman, I. Wellid, L. M. Simbolon, A. Setyawan, and M. F. bin Sukri, “Investigation of automotive air conditioning using eco-friendly R600a as an alternative refrigerant to R134a,†J. Polimesin, vol. 22, no. 1, pp. 35–39, 2024, doi: 10.30811/jpl.v22i1.4463.

R. K. Sahu, Vinay, and A. Das, “Refrigerating effect produced by engine exhaust heat,†Adv. Fluid Therm. Eng., pp. 489–498, 2019, doi: 10.1007/978-981-13-6416-7_45.

I. N. Ardita and I. P. S. Negara, “Pengaruh heat recovery pada sistem refrigerasi pengkondisian udara terhadap performansi sistem,†J. Log., vol. 16, no. 3, pp. 199–203, 2016.

W. Widodo, B. F. T. Kiono, S. H. Winoto, and M. S. K. T. S. Utomo, “A simulation of R32 refrigerant mixing with R1270 to reduce GWP R410A on wall mounted air conditioning,†IOP Publ., vol. 1098, no. 6, pp. 1–7, 2021, doi: 10.1088/1757-899x/1098/6/062111.

G. Fekadu and S. Subudhi, “Renewable energy for liquid desiccants air conditioning system: A review,†Renew. Sustain. Energy Rev., vol. 93, pp. 364–379, 2018, doi: 10.1016/j.rser.2018.05.016.

Y. Sun, J. Wang, and Y. Hu, “Effect of refrigerant/oil solubility on thermodynamic performance of the evaporator working with R600a and DME,†J. Chem. Thermodyn., vol. 154, pp. 1–8, 2021, doi: 10.1016/j.jct.2020.106331.

S. M. Moosania and X. Zheng, “Performance improvement of a high pressure ratio centrifugal compressor by integrated cooling,†Proc. Inst. Mech. Eng. Part G J. Aerosp. Eng., vol. 230, no. 12, pp. 2233–2240, 2015, doi: 10.1177/0954410015622964.

Widodo, B. F. T. Kiono, S. H. Winoto, and T. S. Utomo, “Performance analysis of using hydrocarbon mixed refrigerant r32-r290 as an alternative to R410A in reducing the GWP value of household split air conditioners,†J. Adv. Res. Fluid Mech. Therm. Sci., vol. 107, no. 2, pp. 103–116, 2023, doi: 10.37934/arfmts.107.2.103116.

A. Setyawan, “Enhancing air conditioner efficiency through evaporative cooling of the compressor: field test results,†Int. J. Heat Technol., vol. 42, no. 3, pp. 1073–1080, 2024, doi: 10.18280/ijht.420334.

O. Heriyani, M. Djaeni, and Syaiful, “Thermal-hydraulic performance analysis by means of rectangular winglet vortex generators in a channel: An Experimental Study,†Eur. J. Eng. Technol. Res., vol. 6, no. 3, pp. 150–153, 2021, doi: 10.24018/ejers.2021.6.3.2424.

M. A. Saad, A. E. Tourab, M. H. Salem, and A. Ismail, “Multifaceted analytical and computational fluid dynamics investigations of vortex tube technology for the optimization of seawater desalination efficiency,†Results Eng., vol. 25, pp. 1–12, 2025, doi: 10.1016/j.rineng.2025.104004.

D. Mugisidi, O. Heriyani, P. H. Gunawan, and D. Apriani, “Performance improvement of a forced draught cooling tower using a vortex generator,†CFD Lett., vol. 13, no. 1, pp. 45–57, 2021, doi: 10.37934/cfdl.13.1.4557.

A. I. Rifa’i and Novarini, “pengaruh tekanan refrigeran r-134a terhadap nilai coefficient of performance (COP),†J. Inov., vol. 1, no. 1, pp. 1–5, 2018, doi: 10.37338/ji.v3i2.136.




DOI: http://dx.doi.org/10.30811/jpl.v23i1.6110

Refbacks

  • There are currently no refbacks.


Bookmark and Share


Creative Commons License
This work is licensed under a Creative Commons Attribution-ShareAlike 4.0 International License.

Lisensi Creative Commons

Ciptaan disebarluaskan di bawah Lisensi Creative Commons Atribusi-BerbagiSerupa 4.0 Internasional .

 

Alamat Surat :

Politeknik Negeri Lhokseumawe
Jl. Banda Aceh-Medan Km 280
Buketrata, Lhokseumawe, 24301, Aceh, Indonesia