Pengaruh Penggunaan Abu Vulkanik Gunung Sinabung Sebagai Bahan Subtitusi Parsial Semen Terhadap Kuat Tekan dan Daya Serap Air Mortar

Widayanto Widayanto, Mizanuddin Sitompul

Abstract


This research aims to find out the effect of the use of volcanic ash mount Sinabung on the compressive strength and absorption of mortar and its feasibility for the manufacture of solid concrete bricks and paving blocks that meet the quality standards of building materials in Indonesia. The study was conducted by making a test object in the form of a mortar cube measuring 5x5x5 cm with variations in the composition of volcanic ash as a cement substitution material is 0%, 3%, 6%, 9%, 12%, and 15% against the initial weight of cement, and the cement-water factor is 0.60. Compressive strength and mortar water absorption test is carried out at the age of 28 days. The results showed that the factor of using volcanic ash mount Sinabung as a cement substitution material in mortar with a percentage of 0%, 3%, 6%, 9%, 12%, and 15% had a very real effect on the compressive strength and water absorption of mortar. The greater the percentage of volcanic ash the lower the mortar compressive strength and the higher the absorption of water

Keywords


Mortar; Volcanic Ash; Mount Sinabung; Solid Concrete Bricks; Paving Block

References


Anggarani, P., 2015, Pemanfaatan Abu Vulkanik Gunung Kelud sebagai Bahan Substitusi Semen pada Graut Mortar, Thesis, Universitas Gadjah Mada.

Nurdiansyah, B, Karolina, R., 2017, Pengembangan Bata Beton (Paving Block) Menggunakan Abu Vulkanik Gunung Sinabung yang Diberikan Pembebanan Selama 90 Hari, Jurnal Teknik Sipil USU, Vol. 7, No.1.

Soeherman, O., 2015, Pemanfaatan Abu Vulkanik Gunung Kelud sebagai Bahan Substitusi Semen untuk Graut Mortar pada Beton dengan Metode Pengerjaan Preplaced Aggregate Concrete, Thesis, Universitas Gadjah Mada.

Tindaon, F. dkk., 2010, Komposisi Kimia Abu Erupsi Gunung Sinabung Tanah Karo dan Lumpur Vulkanik Sidoarjo Jawa Timur, Prosiding Semirata BKS_PTN Wilayah Barat. Lhokseumawe.

Sudaryo dan Sucipto, 2009. Identifikasi dan Penentuan Logam Berat pada Tanah Vulkanik di Daerah Cangkringan, Kabupaten Sleman dengan Metode Analisis Aktivasi Neutron Cepat. Seminar Nasional V SDM Teknologi. Yogyakarta




DOI: http://dx.doi.org/10.30811/portal.v13i2.2321

Refbacks

  • There are currently no refbacks.


Copyright (c) 2021 Widayanto Widayanto, Mizanuddin Sitompul

Creative Commons License

Portal: Jurnal Teknik Sipil is licensed under a Creative Commons Attribution-ShareAlike 4.0 International License 

©2018 All rights reserved | ISSN 2085-7454 (print) | 2622-576X (online)